Results 1 to 2 of 2

Thread: K75 Unable to synchronize cylinders

  1. #1

    K75 Unable to synchronize cylinders

    I'm stumped.
    During the winter I removed the throttle body housing and plenum. The TB was thoroughly cleaned of gunk and bypass air screw's O-rings where replaced.
    I am not able to synchronize the cylinders. (ie #1 cylinder reads high while #3 cylinder reads very low, while #2 is somewhere in the middle. The bypass screws can not make the adjustment, i have tried everything.)
    A motorcycle tech well versed in k75 mentioned the butterfly valves are not matted from the factory from the through cleaning and debris removed plus 28 years of riding - 346,000kms.

    Recommended to synchronize the butterfly valves before synchronizing the cylinders. He stated run k75 to operating temp
    then adjust the idle screw to increase the RPM slightly above 950 RPM,
    then close the bypass air screws and with a carb stick adjust the factory set TB screws to balance the valves which worked.
    (I increased the factory set screw between #2 and #3 TB by 3/4 close wise turn.)

    Next step to synchronize cylinders.
    Opened air bypass screws 1 1/2 turns and with a little tweaking the cylinders were balanced, HOWEVER i can not return the 1200 RPM to 950.

    Does anyone have information?

  2. #2
    3 Red Bricks
    Join Date
    Jan 2007
    Location
    Pleasanton, Ca.
    Posts
    4,452
    Bill,


    It's usually a VERY bad idea to touch the linkage screws between the throttle bodies, but that is not helpful to you since you already did it. Note to others: DON'T TOUCH the screws on the linkage between the throttle bodies!!!

    Are you sure the throttle position switch or the fast idle cable is not holding the throttle open? If not, just slowly tighten the bypass screws (while maintaining balance) until the idle is where you want it. Factory says 950 + or - 50. I prefer 1050. It makes for smoother takeoff from a light.






    LONG MAY YOUR BRICK FLY!

    Ride Safe, Ride Far, Ride Often

    Lee Fulton Forum Moderator
    3 Marakesh Red K75Ss
    Mine, Hers, Spare

Similar Threads

  1. Unable to hit forum with Blackberry
    By JoeDabbs in forum Forum Software Specific Help. NOT for bike related questions.
    Replies: 20
    Last Post: 03-22-2017, 08:05 PM
  2. Unable to login using Tapatalk
    By okiegman in forum Forum Software Specific Help. NOT for bike related questions.
    Replies: 1
    Last Post: 07-22-2012, 09:57 PM
  3. Unable to buy tickets
    By cycleman2 in forum Forum Software Specific Help. NOT for bike related questions.
    Replies: 3
    Last Post: 05-01-2010, 04:21 PM
  4. PDA unable to log in on new site
    By indycar in forum Online Central
    Replies: 12
    Last Post: 06-08-2009, 01:46 AM
  5. Help Please: Unable to get into 1st gear.
    By AnnapolisAirhead in forum Airheads
    Replies: 12
    Last Post: 10-12-2008, 01:41 AM

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •