R1100GS Starter Failure?
Rolled my 95 GS out to go to work this morning, turned the key, kickstand up, in neutral, enricher on, headlight turned off via euro switch, kill switch on, fuel pump cycled. I thumbed the starter and it cranked a few times and almost caught. Hit it again and there was a loud clank and the lights on the dash dimmed. Repeated that once more with the same results. Rolled it into the garage and put it up on the centerstand. Hit the starter one last time and got the same thing plus an electrical sound and a puff of smoke from under the front left of the seat. ****! Now all the dash lights are out too. GPS that is direct wired to the battery has power.
The bike had been starting slow all week, seemed to be getting worse as the days went on. Its been much cooler than normal this week so I though that might be part of the slow starting. Battery is 6 months old and has been kept on a tender. I had the starter off last month when I replaced my front timing chain guides and a leaking front crankshaft seal. Didn't do any starter maintenance while I had it off. I installed a new Hall Sensor then too. Any ideas on what I burned up?
May not be related but a week ago, I hit a hard bump on a dirt road and the bike shut off. All lights were still working and it started right back up. It did the same once about 8 months ago too.